Powertrain Plan

Includes the Components Below:

Engine

Gasoline Engine

All internal lubricated parts including but not limited to: (balance shafts, cam bearings, cam tower, camshaft, connecting rods, crankshaft, cylinder block, cylinder head, harmonic balancer and retainer bolt, lifters, oil filter adapter, pistons/piston oil pump and pressure relief valve, piston rings, push rods, rocker arms (cam followers), rod and main bearings, timing belt and timing belt tensioner, timing chain housing (cover), timing chain tensioner, timing gears, timing guides, crankshaft pulley, dipstick and tube, engine mounts, engine oil cooler, engine oil cooler lines, expansion (freeze) plugs, flywheel, flexplate, intake and exhaust (manifolds), oil pan, oil pump housing, seals, temperature sending unit, oil sending unit housing, vacuum pump, valve covers, water pump

Turbocharged/supercharged/rotary/diesel/enhanced engines

All of the above listed parts or equivalent plus: bypass valve, clutch pulley, dampers, cooler, hard lines, injection pump, intercooler and nozzles, supercharger, turbocharger, wastegate controller

Transmission

Automatic

All internal lubricated parts including but not limited to: (bands, bearings, bushings, oil and gas pumps, clutches, drums, gear sets, governor, main shaft, oil supply, continuously variable transmission (CVT) and all internal parts, cooler, cooler hoses and hard lines, dipstick and tube, electronic shift control unit, linkage and drive gear, shift lever knob, shift linkage and cables, throttle valve cable, transmission mounts, transmission pan, vacuum modulator

Standard

All internal lubricated parts including but not limited to: (bearings, bell housing and case, bushings, gear sets, main shaft, forks, synchronizers, transmission case), clutch master cylinder, clutch slave cylinder, shift cable, shift lever knob, transmission mounts

Transfer Case (4X4 Vehicles)

All internal lubricated parts including but not limited to: (actuators/motors, bearings, bushings, chain and sprockets, gears, housing, mounts, shift fork, synchronizers and vacuum engagement components, mounts, transfer case control unit)

Front-Wheel Drive

All internal parts including but not limited to: (axle shafts, bearings, bushings, carrier case, chain and sprockets, constant velocity joints, differential cover, drive shaft support, front hub bearings, locking hub assemblies (4X4), rear hub bearings, universal joints)

Hybrid Vehicle Components

Electrical coolant pump, electrical oil pump, electric motor/generator(s) and all internal components, inverter/converter/transmission control units, power electronics controller, transmission fluid pump, reduction/reducer box and all internal components

Seals and Gaskets

All seals and gaskets on the assemblies listed above

Fasteners

All fasteners for the components within the assemblies listed above

Standard Plan

All Powertrain coverage components, plus:

Steering

All internal lubricated parts including but not limited to: (bearings, bushings, housing/case, rack and pinion equipped valve assembly, sealing rings, sector shaft), center link/drag link, cooler and hard lines, coupling, electric power steering motor, electric steering rack and pinion, fluid reservoir, idler arm, inner/outer tie rods and tie rod ends, boots, pitman arm, power cylinder assembly, power steering pump and pulley, pressure and return hoses, rack mounts and bushings, speed sensor or steering gear equipped pitman shaft and valve assembly, steering main and intermediate shafts (does not include “rear-wheel steering” components)

Front Suspension

Bump stop cushions, control arm shafts, king pins, radius arm, stabilizer support, stabilizer linkage including mounts and bushings, spindle shaft, steering knuckle (spindle), strut/radius rods and bushings, torsion bar mounts and bushings, track bar, upper and lower ball joints including dust boots, upper and lower control arms, wheel bearings and seals

Rear Suspension

Rear suspension equivalents of components listed in Front Suspension section

Brakes

Anti-lock brake module and sensors, assist booster, backing plates, brake pedal shaft, clips and retainers, combination valve, disc brake calipers (and rear caliper actuators), hard lines and fittings, electrohydraulic brakes, master cylinder, parking brake linkage and cables, self-adjusters, springs, wheel cylinders

Fuel Injection

Electronic fuel injection system (including all input/sensors & output/control units, except EGR valve, related to the fuel injection system), fuel rails, idle speed or automatic idle speed assemblies, injectors, powertrain control module (PCM)

Fuel Delivery

Fuel pump, fuel tank and hard lines, fuel tank sending unit

Fasteners

All fasteners for the components within the assemblies listed above

Electrical

Alternator, distributor and coil, convertible top motor, digital and analog instrument cluster, electronic ignition module, engine control unit, electronic rear window motor(s), headlamp assemblies, front and rear windshield wiper motors (including washer pumps), heated back glass, high intensity discharge lamp assemblies, horn assembly, knock sensor, relays, sensors (including oxygen sensor), manually operated switches (specifically turn signal, headlight, dimmer, and wiper switches), mechanically actuated switches, power antenna, power seat motor(s), power sunroof motor(s), power window motor(s) and regulator(s), power door lock(s), power seat motor(s) and transmission(s), power sun roof motor, power window motor(s) and regulator(s), starter button, starter motor, starter relay, starter solenoid, tire pressure monitoring system, voltage regulator, windshield wiper washer pump(s), wiring harness

Air Conditioning

Accumulator, clutch and pulley, compressor and mounting brackets, condenser, drier, evaporator, heater/AC blower motor, high/low pressure cutoff switches, high/low pressure hoses, orifice tube, refrigerant, pressure cycling switch, temperature control programmer, thermostat, thermistor. Freon refrigerant if necessary in conjunction with the repair of the components within this assembly

Hybrid/Electric Vehicles Components

Battery charge controller, controller/electronic throttle control system, electric motor damper, electric AC compressor, hydraulic or electric regenerative braking system, junction block, main battery cable, motor/generator belt tensioner, onboard battery charging system, onboard computer system including all relays, sensors, ECU & ECM (electronic control units/electronic control module), power switch/button, three-phase high voltage cables, voltage inverter reservoir

Cooling

Engine oil cooler, heater control valve, heater core assembly, radiator, radiator fan and clutch, radiator fan motor including fan blade, radiator fan relay, temperature sensor and relay

Safety

Airbag system, seatbelts

Seals and Gaskets

All seals and gaskets on the assemblies listed above

Premium Plan

Covers any breakdown of your vehicle except items that are excluded

Examples of Premium components include:

High-Tech

Automatic leveling system, cruise control actuator and module, electronic instrument panel control module, electronic stability control system, electronic traction control system, GPS/navigation system and antenna assembly, heated seat element and cooling seat components, rollover protection system, and all gauges, sensors, and relays

Entertainment System

Antenna assembly, compact disc player/changer, DVD player and monitor, graphic equalizer, radio and speakers, satellite radio, telephone preview/Bluetooth connectivity

Safety and Security

Heads-up display, night vision system, OnStar® system, remote keyless entry transmitter and receiver module, tailgate and hatchback actuators, theft alarm system

Convenience

Auxiliary power point, buzzer/chime (headlamps on, key in ignition), cigarette lighter, clock, compass, electrical or mechanical gas cover and trunk releases, glove box lamp (excluding bulb), headlight wiper motor transmission, illuminated entry lamp (excluding bulb), illuminated vanity mirrors, memory seat system, trip/mileage computer, trunk lamp (excluding bulb), volt/amp gauge, wiper motor transmission

Miscellaneous

Blend door motors, blower motor resistor (regulates fan speed), door hinges, mechanical seat adjustment, outside mirror remote adjusters, rear hatch or hood struts

Premium Plus Plan

Covers any breakdown of your vehicle except items that are excluded

Examples of Premium Plus components include:

Brake Pad

One replacement of a set of front and/or rear brake pads; brake rotors will be replaced in conjunction with the replacement of brake pads if the thickness of the brake rotor is less than the manufacturer's minimum specification

Battery

One replacement of a battery or the difference between the manufacturer's prorated reimbursement and the total cost of the battery (does not include any Lithium-ion or hybrid batteries)

Headlamps Bulbs

Unlimited replacement of the headlamp bulbs; impact damage is not covered

Belts and Hoses

Replacement of engine belts and hoses including: vacuum pump belt, serpentine belt, power steering belt, alternator belt, supercharger belt, AIR pump belt, air conditioner belt, water pump belt, heater hose, bypass hose, throttle body hose, upper and lower radiator hoses, air conditioning hose, power steering pressure and return hose, air hose, washer hoses, vacuum hoses, fuel hoses, emission system hoses, and transmission hoses

Spark Plugs

One replacement of a set of spark plugs

Windshield Wiper Blades

One replacement of a set of front and/or rear windshield wiper blades and/or inserts

Electrical

Unlimited coverage of fuses, interior and exterior light bulbs including but not limited to: turn signal bulbs, engine compartment lights, running lights, fog lights, stop lights, backup lights, license plate lights, parking lights, trunk light, dome light, courtesy light, visor light, map light, and glove box light (impact damage is not covered)

Wheel Alignment

One wheel alignment